3M MALAYSIA SDN BHD ======================================================================== CHEMICAL SAFETY DATA SHEET ======================================================================== Document id : 06-1223-4 Issue date : 30/06/2006 Version : 2.00 Supersedes date : 10/01/2005 Document status : Issued This CSDS has been prepared by Toxicology Department 3M Malaysia Sdn. Bhd. ------------------------------------------------------------------------ SECTION 1: CHEMICAL PRODUCT AND COMPANY IDENTIFICATION ------------------------------------------------------------------------ Tradename 3M(TM) FASTBOND(TM) CONTACT ADHESIVE 2000-NF LIGHT ORANGE 3M Product ID: 62-4346-7536-9, 62-4346-8430-4, 62-4346-9930-2, 62-4346-9932-8, 62-4346-9939-3, 62-4346-8230-8, 62-4346-8436-1, 62-4346-8535-0, 62-4346-9430-3, 62-4346-9935-1, 62-4346-9535-9 Intended Use of Product waterbased contact adhesive COMPANY IDENTIFICATION ---------------------- Manufacturer's name and address 3M 3M Center St. Paul, Minnesota 55144-1000 USA Importer's name and address 3M Malaysia Sdn. Bhd. Bangunan 3M No. 6, Persiaran Tropicana 47410 Petaling Jaya Selangor Telephone number 03-7806-2888 Emergency telephone number 1-651-7376501 ( 24 hours ) CONTACT POINT ------------- Designation Toxicology Coordinator Telephone number 03-7806-2888 ------------------------------------------------------------------------ SECTION 2: COMPOSITION/INFORMATION ON INGREDIENT ------------------------------------------------------------------------ Ingredient name CAS number Percentage ------------------------------------- ------------------ ------------- WATER 7732-18-5 40.0 - 50.0 POLYCHLOROPRENE 9010-98-4 30.0 - 40.0 GLYCEROL ESTER OF HYDROGENATED ROSIN 65997-13-9 5 - 10.0 PHENOL-ALPHA-PINENE RESIN 25359-84-6 5 - 10.0 TOLUENE 108-88-3 < 3.0 METHYL ALCOHOL 67-56-1 < 2.5 ZINC OXIDE 1314-13-2 < 2 ------------------------------------------------------------------------ SECTION 3: PHYSICAL AND CHEMICAL PROPERTIES ------------------------------------------------------------------------ Physical form,Color,Odor liquid light orange, slight odor of ammonia Water Solubility MOD Boiling point/boiling range = 63.9 C (methanol) Melting point/melting range NOT DETERMINED Vapour pressure N/A Percent Volatile No data available. Evaporation rate = 1 Ether=1 Vapour density = 1.1 Air=1 Specific gravity = 1.1 Water=1 Flash point NONE Autoflammability NOT DETERMINED Flammable Limits - LEL N/A Flammable Limits - UEL N/A Viscosity 200 - 600 centipoise ------------------------------------------------------------------------ SECTION 4: HAZARD IDENTIFICATION ------------------------------------------------------------------------ Risk Phrases Toxic to aquatic organisms. May cause long-term adverse effects in the aquatic environment. ------------------------------------------------------------------------ SECTION 5: FIRST AID MEASURES ------------------------------------------------------------------------ Instructions for Ingestion Do not induce vomiting. Drink two glasses of water. Call a physician. Instructions for Eye Contact Immediately flush eyes with large amounts of water. Get immediate medical attention. Instructions for Skin Contact Flush skin with large amounts of water. If irritation persists, get medical attention. Instructions for Inhalation If signs/symptoms occur, remove person to fresh air. If signs/symptoms continue, call a physician. ------------------------------------------------------------------------ SECTION 6: FIRE FIGHTING MEASURES ------------------------------------------------------------------------ Suitable Extinguishing Media Water spray Carbon dioxide Dry chemical Foam Fire Fighting Procedures Wear full protective clothing, including helmet, self-contained, positive pressure or pressure demand breathing apparatus, bunker coat and pants, bands around arms, waist and legs, face mask, and protective covering for exposed areas of the head. Special Instructions for Fire Fighting Not applicable. ------------------------------------------------------------------------ SECTION 7: ACCIDENTAL RELEASE MEASURE ------------------------------------------------------------------------ Spill Response Cover with absorbent material. Collect as much of the spilled material as possible. Place in a U.S. DOT-approved container. Methods for Disposal As a disposal alternative, incinerate in an industrial or commercial facility in the presence of a combustible material. Dispose of completely cured (or polymerized) wastes in a sanitary landfill. ------------------------------------------------------------------------ SECTION 8: HANDLING AND STORAGE ------------------------------------------------------------------------ Storage Requirements Keep container closed when not in use. Use Instructions Keep container tightly closed. Not intended for consumer sale or use. The Threshold Limit Value for total airborne particulate is 10 mg/m3. The Threshold Limit Value for respirable airborne particulates is 3mg/m3. The results of air monitoring conducted by 3M indicate that spraying two and one half gallons of adhesive over a 30 minute period in an area with limited ventilation results in an exposure to toluene of 1.5 ppm. ------------------------------------------------------------------------ SECTION 9: EXP0SURE CONTROL AND PERSONAL PROTECTION ------------------------------------------------------------------------ TOLUENE (108-88-3) Exposure Limits 188 mg/m3 50 ppm 75 ppm ACGIH: TWA; skin contact contributes to exposure; Table A4 ACGIH: TWA; skin contact contributes to exposure; Table A4 CMRG: STEL; skin contact contributes to exposure; ROHM & HAAS MSDS DAT ED 2/20/01 FOR 11-0018-3267-1. METHYL ALCOHOL (67-56-1) Exposure Limits 328 mg/m3 250 ppm 262 mg/m3 200 ppm ACGIH: STEL; skin contact contributes to exposure ACGIH: STEL; skin contact contributes to exposure ACGIH: TWA; skin contact contributes to exposure ACGIH: TWA; skin contact contributes to exposure ZINC OXIDE (1314-13-2) Exposure Limits 10 mg/m3 2 mg/m3 ACGIH: STEL; Comments: updated per RDC - removed fume and dust and consolidated as respirable ACGIH: TWA; respirable; Comments: updated per RDC - removed fume and dust and consolidated as respirable Recommended Ventilation Do not use in a confined area or areas with little or no air movement. Conduct air monitoring to determine adequacy of ventilation. Provide sufficient ventilation to maintain emissions below recommended exposure limits. If exhaust ventilation is not adequate, use appropriate respiratory protection. Provide ventilation adequate to control vapor concentrations below recommended exposure limits and/or control spray or mist. Eye Protection Avoid eye contact with vapors, mists, or spray. Indirect Vented Goggles Safety glasses with side shields Hand Protection Wear appropriate gloves when handling this material. The following glove material(s) are recommended: nitrile rubber polyethylene/ethylene vinyl alcohol polytetrafluoroethylene (Teflon) fluoroelastomer (Viton) Skin Protection Avoid prolonged or repeated skin contact. Respiratory Protection Avoid prolonged breathing of vapors. Avoid prolonged breathing of spray or mists. Ingestion Do not ingest. Keep out of the reach of children. ------------------------------------------------------------------------ SECTION 10: STABILITY AND REACTIVITY ------------------------------------------------------------------------ Materials to Avoid Not applicable. Hazardous Decomposition Carbon Monoxide and Carbon Dioxide Hydrogen Chloride Aldehydes Ketones Stability and Reactivity Stable Hazardous polymerization will not occur. ------------------------------------------------------------------------ SECTION 11: TOXICOLOGICAL INFORMATION ------------------------------------------------------------------------ Effects from Eye Contact Mild Eye Irritation: Signs/symptoms may include redness, pain, and tearing. Effects from Skin Contact Contact with the skin during product use is not expected to result in significant irritation. Mild Skin Irritation (after prolonged or repeated contact): signs/symptoms can include redness, swelling, and itching. Effects from Inhalation Upper Respiratory Tract Irritation: Signs/symptoms may include cough, sneezing, nasal discharge, headache, hoarseness, and nose and throat pain. Effects from Ingestion Ingestion may cause: Gastrointestinal Irritation: Signs/symptoms may include abdominal pain, nausea, diarrhea and vomiting. ------------------------------------------------------------------------ SECTION 12: ECOLOGICAL INFORMATION ------------------------------------------------------------------------ Environmental Data No data available. Other Ecotoxicity Information U.S. EPA Toxicity Characteristics Leaching Procedure,(TCLP), Method 1311, 40 CFR Part 261, Appendix 2 was run on properly mixed Fastbond 2000 and Spray Activator #1 with the following results: Arsenic <0.2 mg/L, Barium 0.10 mg/L, Cadmium <0.01 mg/L, Chromium <0.05 mg/L, Lead <0.5 mg/L, Mercury <0.2 ug/L, Selenium<0.3 mg/L, Silver<0.05 mg/L, Zinc 53 mg/L. Since regulations vary, consult applicable regulations or authorities before disposal. ------------------------------------------------------------------------ SECTION 13: DISPOSAL INFORMATION ------------------------------------------------------------------------ Product as Sold ------------------------------------------------------------------------ SECTION 14: TRANSPORT INFORMATION ------------------------------------------------------------------------ UN Number IMO Class ICAO Class Special Instructions ** NOT HAZARDOUS FOR TRANSPORT FOR DOT, IMO, OR IATA. ------------------------------------------------------------------------ SECTION 15: REGULATORY INFORMATION ------------------------------------------------------------------------ Symbols N Dangerous to environment Risk Phrases Toxic to aquatic organisms. May cause long-term adverse effects in the aquatic environment. Safety Phrases Do not breathe vapor or spray. Use only in well ventilated areas. S24/25 Avoid contact with the skin and eyes. S26 In case of contact with eyes, rinse immediately with plenty of water and seek medical advice. S28B After contact with skin, wash immediately with plenty of water. Avoid release to the environment. Refer to special instructions/safety data sheets. ------------------------------------------------------------------------ SECTION 16: OTHER INFORMATION ------------------------------------------------------------------------ Reason for Reissue exposure limit change The information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under normal conditions. Any use of the product which is not in conformance with this data sheet or which involves using the product in combination with any other product or any other process is the responsibility of the user.